R69S: Adjusted Service Schedule
This service schedule comes from a variety of sources. Much of it comes from the text of the /2 instruction manual/handbook. This schedule has been modified for my desire to change the oil at 1200 mile intervals. Battery and tire pressure is checked at least monthly. Oil levels are checked at least every 300 miles, but typically with every fuel fill-up.
| mileage | 300 | 600 | 1200 | 2400 4800 9600 12000 16800 19200 24000 26400 |
3600 10800 18000 25200 |
6000 8400 13200 15600 20400 22800 27600 |
7200 21600 |
14400 28800 |
| change engine oil clean drain plug |
x | x | x | x | x | x | x | x |
| clean oil pan/filter | x | x | x | |||||
| check transmission oil | x | |||||||
| change transmission oil | x | x | x | |||||
| check drive shaft oil | x | |||||||
| change drive shaft oil | x | x | x | |||||
| check final drive oil | x | |||||||
| change final drive oil | x | x | x | |||||
| check/tighten spokes | x | x | x | x | ||||
| check air filter | x | |||||||
| replace air filter | x | x | ||||||
| oil brake linkages | x | x | x | x | x | x | ||
| oil clutch lever | x | x | x | x | x | x | ||
| oil center/side stand | x | x | x | x | ||||
| oil mud-guard hinge | x | x | x | x | ||||
| clean/check brake shoes | x | x | ||||||
| check wheel bearings | x | x | ||||||
| repack wheel bearings | x | x | ||||||
| check swing arm bearings | x | x | ||||||
| repack swing arm bearing | x | x | ||||||
| lube rear drive splines | x | x | ||||||
| check wheel axle torques | x | x | x | x | ||||
| check/adj/lube cables | x | x | x | x | ||||
| check all fasteners | x | x | x | x | ||||
| check cylinder base nuts | x | x | x | x | x | |||
| re-torque heads | x | x | x | x | x | |||
| check/adjust valves | x | x | x | x | x | |||
| replace plugs | x | |||||||
| check/gap plugs | x | x | x | x | x | |||
| replace points | x | |||||||
| check/adjust/lube points | x | x | x | x | x | |||
| replace condenser | x | |||||||
| check/adjust timing | x | x | x | x | x | |||
| remove and clean carbs | x | x | x | x | ||||
| adjust carb idle/sync | x | x | x | x | ||||
| clean fuel filters | x | x | x | x | ||||
| clean fuel petcock | x | x | x | |||||
| check steering | x | x | x | x | x | x | ||
| check lighting | x | x | x | x | x | x |
In addition, at 28,800 miles clean the slingers and then start all over again.
